MISSION/SAN XAVIER/EISENHOWER — Accidents

Total: 440 accidents | Fatalities: 1

Date Classification Injury Days Lost Narrative
09/08/2021 HANDLING OF MATERIALS NO DYS AWY FRM WRK,NO RSTR ACT None Employee was lowering metal standpipe, poles shifted over when employee felt pressure on right foot.
09/02/2021 POWERED HAULAGE NO DYS AWY FRM WRK,NO RSTR ACT None Employee was being transported in a bus to end shift. As the bus was traveling, it encountered a series of bumps that caused the bus to bounce. Employee was propelled off EE's seat impacting the top o...
06/30/2021 HANDLING OF MATERIALS NO DYS AWY FRM WRK,NO RSTR ACT None Employee was trying to open product valve on trailer from EE's knees and then decided to sit down to get more leverage and opened product valve. Employee stated that EE applied full force to get valve...
05/25/2021 HANDLING OF MATERIALS DAYS RESTRICTED ACTIVITY ONLY 1d restricted Employee conducted Pre Op, front driver door on van struck and hit employee on right torso putting strain on left knee.
04/21/2021 SLIP OR FALL OF PERSON DAYS AWAY FROM WORK ONLY 2d lost Employee was walking down steps and lost footing, grabbed hand rail causing strain to left arm.
04/01/2021 HANDLING OF MATERIALS NO DYS AWY FRM WRK,NO RSTR ACT None Employee was performing an inspection on the lime mill, as employees was performing inspection they noticed the floor was getting flooded with water mixed with lime. Employee then got the Submersible...
01/16/2021 POWERED HAULAGE NO DYS AWY FRM WRK,NO RSTR ACT None Employee was moving man basket with a forklift, the man basket base/weight was not secured with the rods that hold the basket to base. The basket tipped off of the base and fell forward toward the tru...
10/17/2020 MACHINERY NO DYS AWY FRM WRK,NO RSTR ACT None while rotating SAG mill to perform a gear alignment, a mill ball bounced out striking IE in mouth requiring 3 sutures.
10/16/2020 HANDTOOLS (NONPOWERED) DAYS RESTRICTED ACTIVITY ONLY 3d restricted Employee was repositioning jack pad with pry bar, heard pop felt pain in left elbow.
10/14/2020 MACHINERY DAYS RESTRICTED ACTIVITY ONLY 4d restricted Pushed bolt back into cutting edge with hand while impact was ran, impact spun bolt and cut through EE's glove cutting right middle finger.
10/01/2020 MACHINERY DAYS RESTRICTED ACTIVITY ONLY 2d restricted Employee was repositioning right leg for leverage on the grinder when right foot slipped. While slipping they reached for the handrail in front of them to maintain balance which caused the grinder to...
09/10/2020 MACHINERY NO DYS AWY FRM WRK,NO RSTR ACT None Used power tool on exhaust flange and rust and debris went over safety glasses and into Left eye.
05/04/2020 HANDLING OF MATERIALS DAYS AWAY FROM WORK ONLY 4d lost Employee went to move a traffic cone from out of the street and twisted a knee.
04/21/2020 HANDLING OF MATERIALS DAYS RESTRICTED ACTIVITY ONLY 12d restricted EE was placing 4 cable bridal ring onto crane hook. Crane hook safety latch pinched right middle finger.
04/20/2020 HANDLING OF MATERIALS DAYS RESTRICTED ACTIVITY ONLY 4d restricted Employee was removing right wheel tires on Haul Truck when arm was pinched between reaction arm and wheel assembly.
04/06/2020 HANDLING OF MATERIALS DAYS RESTRICTED ACTIVITY ONLY 14d restricted Employee was trying to move an impeller from 1 pallet to another, when lifting it they heard their lower back pop .
03/18/2020 HANDLING OF MATERIALS DAYS RESTRICTED ACTIVITY ONLY 5d restricted Employee was replacing bags in Number 3 Filter. As employee lifted and removed each sector and cut off each bag and replaced it with a new filter bag employee felt pain on left side of back.
02/19/2020 FIRE ACCIDENT ONLY None Uncontrolled fire occurred at the #1 standard crusher polyurethane / rubber screens in the secondary crusher building. 1 contractor and 1 Asarco employee were cutting retaining bolts with a oxygen/ace...
01/20/2020 STEPPING OR KNEELING ON OBJECT NO DYS AWY FRM WRK,NO RSTR ACT None Employee was walking down the stairs to the South SAG on the grind floor. Employee stepped on a rock on the grating just below the last step of the staircase on the main floor decking. This caused emp...
01/10/2020 SLIP OR FALL OF PERSON DAYS AWAY FROM WORK ONLY 88d lost The water was drained from the secondary containment vessel and was hoisted onto the boom truck bed. At approximately 10:50am the employee fell off the back/left side of the truck bed onto the wash pa...
01/06/2020 HANDLING OF MATERIALS DAYS RESTRICTED ACTIVITY ONLY 6d restricted While tossing a 15 lb dust filter cartrage over a handrail employee smashed left ringfinger between a light post and the filter cartridge. Immediately felt the pain and blood run down finger. When emp...
01/06/2020 HANDLING OF MATERIALS DAYS RESTRICTED ACTIVITY ONLY 7d restricted While Shoveling employee has been feeling a strain in left elbow. Employee feels that the pain is from prolonged exposure to shoveling. Employee is new to these tasks.
12/04/2019 HANDLING OF MATERIALS DAYS RESTRICTED ACTIVITY ONLY 8d restricted EE was taking a new return idler from the back of a mule, just as they lifted idler from back of mule to about waist high, mid back begin to spasm. EE immidiately dropped the idler back down to the be...
10/31/2019 POWERED HAULAGE DAYS RESTRICTED ACTIVITY ONLY 5d restricted At 7:45 pm EE was loading the first truck of the shift. When EE went into the dig face for the second bucket, the bucket skipped off a boulder and jarred the loader whipping EE around in the cab. Init...
10/31/2019 NONPOWERED HAULAGE NO DYS AWY FRM WRK,NO RSTR ACT None Employee was loading tripper car railing on a rail dolly and was in the process of securing the rail to the dolly when the weight of the rail shifted causing the dolly to tip forward. The handle of t...
10/21/2019 HANDLING OF MATERIALS DYS AWY FRM WRK & RESTRCTD ACT 9d lost, 8d restricted EE had tipped the stand to try to slide it into position when the stand rocked back into the flat position and pinched EE's right pinky finger against the top of the stand and the front part underside...
10/19/2019 MACHINERY NO DYS AWY FRM WRK,NO RSTR ACT None When the pump was started, the discharge line rotated on the clamp causing the pipe being used to strike EE on the right side of the forehead/brow, lacerating brow. EE was knocked back into the sidewa...
10/07/2019 STRIKING OR BUMPING NO DYS AWY FRM WRK,NO RSTR ACT None EE walked around the dipper and scraped a leg against the #8 tooth. The tooth had a sharp burr on it from when we pushed the dipper away from the high wall with a dozer so we could safely work on it....
09/22/2019 HANDTOOLS (NONPOWERED) DAYS RESTRICTED ACTIVITY ONLY 10d restricted While using a 3 ton come-a-long to remove the left dipper handle pin from the 518 dipper, the pin jumped approximently an inch causing EE to move suddenly and tweek EE's back on the right side. At fir...
08/11/2019 STRIKING OR BUMPING DAYS RESTRICTED ACTIVITY ONLY 5d restricted At approximately 6:45 am EE was getting into 503 man van. While getting in, EE hit EE's left knee on a seat spring that is sticking out of the seat cover.
08/08/2019 HANDLING OF MATERIALS DAYS RESTRICTED ACTIVITY ONLY 5d restricted At approximately 17:15 EE and co-worker were performing a bit change on the 587 drill. EE was in a bent over position while trying to pull the bit basket straight out of the deck. After several attemp...
07/25/2019 HANDLING OF MATERIALS DAYS AWAY FROM WORK ONLY 53d lost Two employees had stood the jack pad on its side and rolled it into position for installment, when suddenly they had lost their grip from the jack pad. Injured employee was in the process of getting o...
07/06/2019 FALL OF FACE/RIB/PILLAR/SIDE/HIGHWALL DAYS RESTRICTED ACTIVITY ONLY 13d restricted While rerouting the power cable for the 518 shovel, over a berm and down a bench, EE was struck by boulder (approximately 2 foot in circumference) to right leg. The boulder struck EE on the front side...
06/26/2019 SLIP OR FALL OF PERSON DAYS RESTRICTED ACTIVITY ONLY 5d restricted EE walked over from EE's truck shop office to North mill maintenance to retrieve items from EE's office. Upon stepping from dirt to concrete porch out front of the building EE miss stepped or caught...
06/12/2019 HANDLING OF MATERIALS DAYS AWAY FROM WORK ONLY 2d lost Rolling 1 cylinder off of another for proper positioning on pallet, subjects finger was pinched between cylinders.
04/21/2019 SLIP OR FALL OF PERSON DAYS RESTRICTED ACTIVITY ONLY 3d restricted Operator slipped boarding water truck. They managed to catch themselves with their right hand, causing a pop in the right wrist. Operator then drove truck back to tie-down.
04/01/2019 STRIKING OR BUMPING NO DYS AWY FRM WRK,NO RSTR ACT None Employee was moving about on a grating at the North Mill where metal parts and motors are stored. EE was trying to find a motor with a nameplate and bumped EE's shin into a metal beam and split open...
03/03/2019 HANDLING OF MATERIALS DYS AWY FRM WRK & RESTRCTD ACT 14d lost, 10d restricted Lifting cable for shovel and drills at a berm height, causing pain in the groin area.
02/28/2019 HANDLING OF MATERIALS DAYS RESTRICTED ACTIVITY ONLY 5d restricted Lifting 30 pound tire chocks and strained lower back.
02/26/2019 HANDLING OF MATERIALS DAYS RESTRICTED ACTIVITY ONLY 59d restricted EE was working on E-21/E-23 chute on the first landing. EE lifted a 12"" x 24"" liner out of the truck and carried it over to the concrete platform at the base of the transfer tower. As EE stepped up...
02/25/2019 SLIP OR FALL OF PERSON DAYS RESTRICTED ACTIVITY ONLY 13d restricted Went to mount a dozer, when foot slipped and slammed right knee onto the tracks.
02/02/2019 HANDLING OF MATERIALS DAYS RESTRICTED ACTIVITY ONLY 17d restricted Crushing injury to the right middle finger at the tip. (pinch point) from motor sheave and v-belt.
01/31/2019 HANDLING OF MATERIALS DYS AWY FRM WRK & RESTRCTD ACT 5d lost, 4d restricted Employee was installing scalper plates on # 4 rod mill discharge box. The scalper plate was already installed and employee was in the process of installing a 2nd one. As employee was sliding down the...
01/11/2019 SLIP OR FALL OF PERSON DAYS RESTRICTED ACTIVITY ONLY 27d restricted Employee was operating the 530 Loader when EE dismounted the loader to check the left front tire. As EE was dismounting the hydraulic ladder EE lost EE's footing on the last step and hit EE's left hee...
01/04/2019 MACHINERY NO DYS AWY FRM WRK,NO RSTR ACT None Mechanic was tightening up a few loose cutting edge bolts on rubber tire dozer. Employee was using a impact gun with a 1 1/2inch socket to tighten the bolts, holding the impact over head when the impa...
12/24/2018 STRIKING OR BUMPING DAYS AWAY FROM WORK ONLY 48d lost Employeee was exiting DCS out the rear door when the employee hit the cement curb at floor level with left foot and twisted lower ankle/leg area and was unable to walk on it afterwards
12/21/2018 MACHINERY NO DYS AWY FRM WRK,NO RSTR ACT None Employee was using a rivet buster to knock in bolts. One of the bolts gave which caused the liner to fall. From this the rivet buster shot up and hit the employee by right eye.
12/17/2018 HANDLING OF MATERIALS DAYS AWAY FROM WORK ONLY 132d lost Employee retrieved a 5 gallon bucket filled with oil from the back of pickup truck. After carrying the bucket from the vehicle, the employee using left arm, lifted the 5 gallon bucket, weighing ~40 lb...
12/02/2018 SLIP OR FALL OF PERSON DAYS RESTRICTED ACTIVITY ONLY 28d restricted Employee was observing Haul Truck Dump from on top of the dump berm. 316 While climbing down the berm, when EE's foot touched the ground, EE's leg buckled causing EE to fall to the ground. In EE's att...
11/12/2018 POWERED HAULAGE DAYS RESTRICTED ACTIVITY ONLY 13d restricted Employee was operating the 532 Loader, and attempting to bring down a section of overhanging material. When the overhanging material broke loose and fell into the bucket the rear-end of the loader lif...